Uji daya mesin diesel dengan hot EGR menggunakan bahan bakar campuran biosolar, metanol kadar rendah, dan jatropha

Yafid Effendi; Syaiful Syaiful

doi:10.24127/trb.v8i2.1030

Uji daya mesin diesel dengan hot EGR menggunakan bahan bakar campuran biosolar, metanol kadar rendah, dan jatropha

Yafid Effendi, Syaiful Syaiful

Abstract

Motorized vehicles that are very suitable for transportation and heavy equipment vehicles are diesel engines, because their high combustion efficiency, reliability, fuel flexibility, and low fuel consumption make diesel widely used in several countries. The purpose of this study was to determine the effect of using a mixture of biosolar fuels, low levels of methanol and jatropha on power in a diesel engine using the hot Exhaust Gas Recirculation (EGR) system. This study uses an experimental method, using a 4JB1 diesel engine, the percentage of biodiesel fuel mixture, low levels of methanol and jatropha, Low Purity Methanol has a moisture content of 24.88%. The ratio of biosolar mixture, methanol and jatropha used are D85LPM5J10, D80LPM10J10, D75LPM15J10, D75LPM5J20, D70LPM10J20, D65LPM15J20, D65LPM5J30, D60LPM10J30 and D55LPM15J30. EGR openings vary from 0%, 25%, 50%, 75% and 100%. The test is carried out at a constant speed of 2000 rpm and is given a load of 25%, 50%, 75% and 100%. This study uses a dynamite brand Land & Sea dynamite. The results of this study are the use of EGR resulted in increasing the value of brake power. The effect of the fuel mixture causes the value of brake power tends to fall compared to D100. When using D85LPM5J10, D80LPM10J10, D70LPM10J20 and D55LPM15J30 at low loads (25%) there is an increase in power by 12.03%, 7.50%, 5.01%, and 5.97%. Keywords: Power, Engine, Diesel, LPM, Jatropha, EGR.

Full Text:

PDF

References

. Zhiqiang Guo, Tianrui Li, “Combustion and emission characteristic of blends of diesel fuel and metanol to diesel”, International Journal of Fuel, Number 90, ScienceDirect, 2011. [2]. Asif Faiz, Walsh Michael P, Weaver Christopher S,”Air Pollution From Motor Vehicles, Standards and Technologies for Controlling Emissions”, The World Bank Washington, D.C, USA, 1996.

. Lei Zhu, C.S. Cheung, W.G. Zhang, Zhen Huang,”Emissions characteristic of a diesel engine operating on biodiesel and biodiesel blended with ethanol and metanol”, International Journal of the Total Enviroment, Number 408, ScienceDirect, 2010. [4]. M. Senthil Kumar, A. Ramesh, B. Nagalingham, 2003, “An Experimental Comparison of Methods to Use Metanol and Jatropha Oil in a Compression Ignition Engine”, Department of Mechanical Engineering, Indian Institute of Technology Madras, Chennai, India. [5]. Cenk Sayin, Ahmet Necati, Mustafa Canakci, 2009, ”The Influence of operating parameters on the performance and emissions of a DI diesel engine using metanol-blendeddiesel fuel”, International Journal of Fuel, Number 89, ScienceDirect. [6]. Vinod Singh Yadav, “Perfomance and emission studies of direct injection C.I. engine in duel fuel mode (hydrogen-diesel) with EGR”, International Journal of Hydrogen energy, Number 37, ScienceDirect, 2012. [7]. Heywood, John B.L, 1988, “Internal Combustion Engine Fundamentals”, McGraw-Hill, Inc, United States of America. [8]. V. Pradeep, R.P. Sharma, 2007, “Use of HOT EGR for NOx control in a compression ignition engine fuelled with bio-diesel from Jatropha oil”, International Journal of Renewable energy, Number 32, ScienceDirect. [9]. Avinash Kumar Agrawal, Shrawan Kumar Singh, Shailendra Sinha and Mritunjay Kumar Shukla, 2003, “Effect of EGR on the Exhaust Gas Temperature and Exhaust Opacity in

TURBO p-ISSN: 2301-6663, e-ISSN: 2447-250X Vol. 8 No. 2. 2019 161

Compression Ignition Engines”, Kanpur 208 016, India. [10]. Philip Kristanto & Ricky Winaya, 2003, “Penggunaan Minyak Nabati Sebagai Bahan Bakar Alternatif Pada Motor Diesel Sistim Injeksi Langsung”, Jurnal Teknik Mesin Volume 5 Nomor 1.

DOI: http://dx.doi.org/10.24127/trb.v8i2.1030